Country Flame IWZC-02 Manual de usuario

INGLENOOK™ MODEL IWZC-02 ZERO CLEARANCE NON-CAT FIREPLACES OWNERS MANUAL © 2006 Version: 7.0 1This manual was written to ensure safe, efficie

INGLENOOK FIREPLACE OPERATION FUEL The Inglenook should be fueled with seasoned cordwood. Hardwoods will provide more energy per pound of wood cons

COMBUSTION CONTROL The Inglenook is not designed to operate with a flue damper. As is standard practice with hi-tech high efficiency fireplaces, the

FIGURE 2: HIGH BURN COMBUSTION AIR DAMPER SETTING CAUTION must be used when operating the Inglenook Fire

change in the flame pattern. The flames will be slow and intermittent and may appear dirty if the wood is too wet i.e., a moisture content of 20% and

2. Negative Pressure As the Inglenook fire burns, the exhaust gases are drafted up and out of the chimney system. The Inglenook Fireplace system is

FIGURE 5: CHIMNEY INSTALLATION DIMENSIONS 7. Poor Chimney Draft Perform the following simple test of your chimney draft. With no fire

MAINTAINING YOUR INGLENOOK FIREPLACE CREOSOTE When wood is burned slowly, it produces tar and other organic vapors which combine with expelled moist

4. Always use a dry chemical fire extinguisher, baking soda or sand to control the fire. Do not use water as it may cause a dangerous steam explosi

DOOR(S) INSTALLATION The Inglenook doors have been mounted and checked for proper fit at the factory. If the doors are removed for any reason, care

hazardous to use. Inglenook Fireplace replacement glass can be purchased through one of Country Flame’s authorized dealers. DO NOT OPERATE the Ingle

TABLE OF CONTENTS COUNTRY FLAME LIMITED WARRANTY... 4 FOREWARD

DOOR GASKET REPLACEMENT Remove the doors from the unit. Place the doors, face down on a protective surface to ensure no marring or scratching occurs

FIREPLACE INSTALLATION INGLENOOK FIREPLACE LOCATION 1. The best location for your fireplace is determined by considering the location of windows, d

HEARTH EXTENSION REQUIREMENTS The Inglenook Fireplace can be installed directly on a combustible or non-combustible base or directly on the floor. I

3. Frame the Inglenook Fireplace with vertical studs on each side of the fireplace. These studs should run from floor to ceiling as shown in Figure

INSULATED CHASE CONSTRUCTION FIGURE 13: INSULATED CHASE FACING 1. Combustible material must be installed flush with the fireplace. It may not

FIGURE 14: COMUSTIBLE FACING FIGURE 15: NON-COMBUSTIBLE FACING MANTEL CLEARANCES: Option 1: When in

HOT AIR DUCT INSTALLATION There are many different types of hot air ducting systems in the marketplace today. Only a hot air duct system that has be

FIGURE 18: HOT AIR DUCT KIT MULITPLE LOCATION INSTALLATION ot air duct outlets must be installed with the fo

Inglenook Fireplace has not been tested for a Central forced air kit and should not be used in such applications. 7. Use only Country Flame approved

OUTSIDE AIR KIT INSTALLATION A minimum of a four (4) inch hole is to be made in the outside wall of the house at the specified location for the fresh

OUTSIDE AIR KIT INSTALLATION ... 29 ELECTRICAL LINE IN

ELECTRICAL LINE INSTALLATION 120 VOLTS AC FOR BLOWER SYSTEM The Inglenook blower system requires a 120-volt alternating current, 15-ampere, 60-Her

BLOWER OPERATION Operation of the blower system is relatively simple. After the fire has generated enough heat, the blower system will automat

THE CHIMNEY CHIMNEY INSTALLATION 1. If possible, always install an approved chimney system in an interior chase of the home. This will provide bet

4. MINIMUM CHIMNEY HEIGHT: The chimney must be a minimum of 8’above top of fireplace. The chimney must extend a minimum of three feet above the high

REMINDER: The chimney must extend at least three feet above the highest point where it passes through the roof of a building. The chimney must be at

FIGURE 24: EXAMPLE MULTIPLE CHIMNEY INSTALLATION (INTERIOR SPACE) Version: 7.0 35

Class A AC CHIMNEY INSTALLATION (AIR COOLED CHIMNEY) Version: 7.0 36FIGURE 25: AC CHIMNEY

FIGURE 26: EXAMPLE CHIMNEY INSTALLATION (exterior space) Version: 7.0 37

CHIMNEY CHASE AND MULTIPLE TERMINATIONS For the purpose of this manual, a chimney chase is considered a part of the chimney system rather than part o

CHIMNNEY TYPE WARNING: Use only 8-inch type HT or Air Cooled Chimney Listed per UL 103 or ULC S269. APPROVED CHIMNEY PRODUCT TYPE HT EIGHT INCH AP

COUNTRY FLAME LIMITED WARRANTY 900 George Street, Marshfield, MO. 65706 Country Flame Technologies warrants to you, the original consumer purcha

INSTALLATION ITEMS (REQUIRED) Item Required Required/Installation Inglenook Fireplace 1 each Inglenooks hold down system (mobile home only

APPENDIX A INGLENOOK FIREPLACE SPECIFICATIONS Fireplace Weight (with doors, glass, grills, and firebrick) 650 pounds Fireplace Weight (w/o doors

problems occur or your glass needs replacement, contact one of the many authorized Country Flame dealers for assistance in replacing the glass. DO NO

APPENDIX B CLEARANCE TO COMBUSTIBLES The following clearances meet the minimum requirements for a safe installation Sidewall: 18 inches measured f

APPENDIX C REPLACEMENT PARTS Part Number Description Number per Inglenook PP-1194 Ash Grate 1 IN-201 Log Retainer/Security Kit 1

REPLACEMENT PART DRAWINGS _______________________________________________________________________ _______________________________________________

________________________________________________________________________ _______________________________________________________________________

________________________________________________________________________ Version: 7.0 47

________________________________________________________________________ ____________________________________________________________________

________________________________________________________________________ ________________________________________________________________________

________________________________________________________________________ Version: 7.0 50

APPENDIX D WARNING LABELS Below is a sample list of the warning labels attached to the Country Flame Inglenook Fireplace product. It is important t

WARNING LABEL: Electrical Hazard WARNING LABEL: FIRE HAZARD IF INTERFERENCE WITH AIRFLOW WARNING LABEL: INCLUDED ON BLOWER FAN LABEL:

Fold Here - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -

REQUIRED WARRANTY INFORMATION Name ________________________________________________ Address

FOREWARD Country Flame Technologies, A Division of American Products, LLC. and its employees would like to thank you for the purchase of an Inglenook

Version: 7.0 7SAFETY RULES Warning: An outside air kit must be installed on the Inglenook Fireplace. Inglenook air openings are never to

8 WARNOCK HERSEY SAFETY LABEL Version: 7.0

THE INGLENOOK FIREPLACE INTRODUCTION The Inglenook hi-tech fireplace is an energy efficient, non-catalytic, heat circulating, closed combustion syst